[AMRadio] BC-610 Modulator feedback - and notes


Rbethman rbethman at comcast.net
Sat Mar 18 09:30:03 EST 2006


Rick,

Additionally, there should be NO shield on the 2A3s.  The entire
transmitter was designed to function with CONVECTION or OPEN air cooling.

There is only ONE tube that has a "shield".  It is the oscillator deck
6L6.  It SHOULD be a metal jacketed tube.

The 1/4 X 20 bolts on top of BC-610(X)s were intended for the mounting
of the BC-939(X) antenna tuners.  Since the BC-614(X) speech amp is
fully enclosed w/o vents, I, for one, would be very hesitant to use it
on top of the BC-610(X).  All the heat from below would add to the heat
inside the speech amp.  The components "probably" weren't designed for
THAT additional heat.  The BC-614(X) has a long enough connecting cable
to place it on the operating bench.

Pay close attention to WB2FCN, Jim!  He restored my first one.  He has
"carnal" knowledge of these BEASTS and has helped MANY get them up and
going.

I've also resent this to INCLUDE the T-368 BC-610 group, WHICH, you may 
wish to join Rick.

Bob - N0DGN

James M. Walker wrote:

> I'll bet you a nickel the bias supply has a problem, the plate supply
> for the 2A3s is not normal the plate supply is achieved by putting a
> negative voltage on the 2A3s cathode to raise hte plate to 360 volts.
>
> Sounds like the bias supply voltage is off. Check the manual and then
> the components that provide voltage to the 2A3s
> Jim
> WB2FCN
> YMMV
>
> ----- Original Message ----- From: "Rick Brashear" <rickbras at airmail.net>
> To: "Discussion of AM Radio" <amradio at mailman.qth.net>
> Sent: Friday, March 17, 2006 6:10 PM
> Subject: Re: [AMRadio] Modulator feedback
>
>
>> Thanks Mike.  I just made a discovery about the 2A3 A-F drivers.  I 
>> had a set of matched NOS RCA tubes in there.  The feedback seemed to 
>> be coming from the area of those tubes more so than anywhere else.  
>> So, I exchanged them for another pair I have and it seemed to help 
>> quiet the feedback. Obviously, microphonics in the 2A3's is a 
>> factor.  Next I looked for shields for the tubes, but have none, so I 
>> used a "poor man's shield", a couple of pieces of aluminum foil.  It 
>> helped considerably!  As a matter of fact, I could then advance the 
>> audio of the speech amp enough to achieve good modulation.  So, I am 
>> now on a quest to find some way of shielding the 2A3's.  I'm afraid 
>> my temporary foil shields would cause the tubes to over heat, plus 
>> it's not the best way of doing it.  Have you had any experience with 
>> this?  I wonder if the 100th's are also part of the problem.  I 
>> really think the "talk back" is coming from the modulation 
>> transformer, which I can live with.  I just have to get the feedback 
>> out of it.
>>
>> Thanks for your assistance and advice,
>> Rick/K5IZ
>>
>>
>>
>> Mike Sawyer wrote:
>>
>>> Rick,
>>>    The UTC may work so don't discount it. Those I and H model 
>>> transformers were only about half the size as the D and E models. I 
>>> can't think of the company that made them but they were 
>>> substantially different then the earlier models. As always, your 
>>> mileage may vary.
>>> Mod-U-Lator,
>>> Mike(y)
>>> W3SLK
>>>
>>>
>>
>>
>> ______________________________________________________________
>> AMRadio mailing list
>> Home: http://mailman.qth.net/mailman/listinfo/amradio
>> Help: http://mailman.qth.net/mmfaq.html
>> Post: mailto:AMRadio at mailman.qth.net
>> AMfone Website: http://www.amfone.net
>> AM List Admin: Brian Sherrod/w5ami, Paul Courson/wa3vjb
>>
>>
>>
>
>
> ______________________________________________________________
> AMRadio mailing list
> Home: http://mailman.qth.net/mailman/listinfo/amradio
> Help: http://mailman.qth.net/mmfaq.html
> Post: mailto:AMRadio at mailman.qth.net
> AMfone Website: http://www.amfone.net
> AM List Admin: Brian Sherrod/w5ami, Paul Courson/wa3vjb
>

-- 
Bob - NØDGN
                       Bob Bethman - NØDGN
           \\"""//                                \\"""//
            (@ @)                                  (@ @)
+-------oOOo-(_)-oOOo--------------------------oOOo-(_)-oOOo-------+
| NØDGN AMRadio Manassas, VA    |    REAL Tube Radio and AM        |
+-------------------------------+----------------------------------+
|       Manassas Radio - Home of Homemade Kielbasa & Pirogi        |
+-------------------------------+----------------------------------+
| Bob Bethman                \\\|///     " The absence of a danger |
| rbethman(at)comcast.net   \\ ~ ~ //      signal does *NOT* mean  |
|                           (/ @ @ /)      that everything is OK " |
+-------------------------oOOo-(_)-oOOo----------------------------+
|               <http://home.comcast.net/~rbethman>                |
| 1 BC-61ØI w/BC-614I,1 T-213/GRC-26 w/BC614I 1 '51 Collins R-390A |
|  SP-600/NR Type 159, Heath DX-60, Apache, Mohawk, SX-101, HT-32A |
+-------.oooO---Oooo.---------------------------.oooO---Oooo.------+
|       (    ) (    )                           (    ) (    )      |
|        \  (   )  /                             \  (   )  /       |
|         \ _) ( _/                               \ _) ( _/        |
+------------------------------------------------------------------+
|           Amateur Astronomer - Celestron Nexstar 8               |
|             12" f5 Dob coming soon!  Being built                 |
|                          Meade ETX-6Ø                            |
|           38 Deg 46'48.62"' N - 77 Deg 28'26.89" W               |
+------------------------------------------------------------------+
|   Opinions expressed are that of my own and do not necessarily   |
|         coincide with or represent those of ANYONE else          |
+--------------------------.oooO---Oooo.-------------------------+
                           (    ) (    )
                            \  (   )  /
                             \ _) ( _/
|ALL E-mail received and sent scanned by AVG & Norton System Works |




______________________________________________________________
AMRadio mailing list
Home: http://mailman.qth.net/mailman/listinfo/amradio
Help: http://mailman.qth.net/mmfaq.html
Post: mailto:AMRadio at mailman.qth.net
AMfone Website: http://www.amfone.net
AM List Admin: Brian Sherrod/w5ami, Paul Courson/wa3vjb




More information about the AMRadio mailing list

This page last updated 20 Oct 2017.